Large Reciprocating Lubricant XL-700™

XL-700

MATERIAL SAFETY DATA SHEET

Effective 
XL-700 is a diester based synthetic lubricant specifically formulated for use in Ingersoll-Rand’s complete
family of Large Reciprocating Air Compressors.
1. PRODUCT IDENTIFICATION: Mixture-Chemical Family: Diester
2. HAZARDOUS INGREDIENTS: The components of this product are not listed as hazardous 
or toxic according to OSHA (29 CFR OSHA 1910.1200), NTP, IARC and SARA 313.
Hazardous Materials Identification System (HMIS):
Health Flammability Reactivity Basis Hazard Ratings Key:
1 1 0 — 4 = Highest 0 = Lowest
3. PHYSICAL DATA:
Boiling Point: >660°F Pour Point: -30° F 
Vapor Pressure: <0.02 mmHg @ 300° F Specific Gravity: 0.95 @ 15.5°
Vapor Density: Not volatile Percent Volatile: Not volatile
Solubility in Water: Nil Evaporation Rate: Not volatile
Appearance: Clear red fluid Odor: Mild ester odor
4. FIRE AND EXPLOSION HAZARD DATA:
Flash Point: 480° F – No flash to maximum temperature tested 400° F/204° C 
(Test method: Pensky-Martens Closed Cup) 
Method Used: COC
Autoignition Temperature: 770° F (410° C)
Fire Point: 550° F
Flammable Limits: Not established
Fire Fighting Media: Water spray, dry chemical, foam or carbon dioxide
Fire Fighting Procedures: Use water to keep fire-exposed container cool. Wear self-contained 
breathing apparatus and full turn-out gear to fight fire. Water or foam may cause frothing.
Special Fire and Explosion Hazard: None expected
5. HEALTH HAZARD:
Threshold Limit Value: Not established (Treat as mineral oil: 5mg/meter cubed)
Effects on exposure: Prolonged or repeated skin contact may tend to remove natural skin oils, thus 
leading to possible irritation and dermatitis.
Medical Conditions Generally Aggravated by Exposure: May aggravate previous skin condition.
Skin Contact: With repeated contact, a skin defatter. May cause redness or mild irritation.
Skin Absorption: Not established 
Ingestion (Acute): Not established
Inhalation (Acute): Not established
Eyes: May be mildly irritating.
Systemic & Other Effects: Not established
XL-700™6. REACTIVITY DATA:
Stability: Stable. Will not react violently with water.
Incompatibility: Avoid contact with strong oxidizers, such as liquids chlorine, concentrated oxygen, 
sodium hypochlorite or calcium hypochlorite.
Hazardous Decomposition: Burning will produce oxides of carbon.
Hazardous Polymerization: Will not occur.
Conditions to Avoid: Open flames.
7. HANDLING PRECAUTIONS:
Exposure Guidelines: Not established, OSHA TLV/TWA 5mg/m3oil mist can be used.
Ventilation: Local exhaust to capture vapor, mist or fumes, if necessary.
Respiratory Protection: Use NIOSH-approved equipment: filter; fume,or mist respirator under misty
conditions.
Skin Protection: For prolonged use, use chemical resistant gloves to minimize skin contact.
Eye Protection: Use chemical splash goggles when contact may occur.
Special Handling and Storage: If splashing occurs, use apron. Do not get in eyes, on skin or 
clothing. Wash thoroughly after handling.
8. ENVIRONMENTAL AND DISPOSAL INFORMATION:
Steps to be Taken in Case of Spills: Prevent spread of spill. Absorb with sand or an inert, 
absorbent material. Sweep or scoop up and remove.
Waste Disposal Method: Dispose of in accordance with local, state or federal laws.
9. FIRST AID:
Eyes: Flush with water for at least 15 minutes. Hold eyelids open while flushing. If irritation persists, 
get medical attention.
Skin: Remove contaminated clothing and wash skin thoroughly with soap and water.
Ingestion: Do not Induce vomiting. Get medical attention immediately.
Inhalation: Remove to fresh air .Get medical attention if discomfort persists.
10. PREPARED BY: Ingersoll-Rand
Note: This information is furnished without warranty, representation, inducement or license of any kind,
except that it is accurate to the best of Ingersoll-Rand's knowledge or obtained from sources believed by
Ingersoll-Rand to be accurate, and Ingersoll-Rand does not assume any legal responsibility for use or
reliance upon same. Customers are encouraged to conduct their own tests. Before using any product,
READ ITS LABEL.